Why McLaren's clever diffuser trick is legal

The clever diffuser solution adopted by McLaren was a big talking point of Formula 1's pre-season testing weekend, but just how and why has it opted to chase this development?

Why McLaren's clever diffuser trick is legal

The intrigue surrounding the MCL35M's diffuser lies in the central section and what the team has done to work around the new restriction on the height of the strakes that lie within the diffuser.

On the face of it, the regulations introduced for 2021 require the strakes to be 50mm shorter than in previous seasons (3.7.9 b - marked in red, below).

FIA 2021 Regulations

FIA 2021 Regulations

Photo by: FIA

However, as you can see, the central 500mm of the car is excluded, due to the extra headroom needed to create the boat tail section in the centre of the diffuser.

However, in an attempt to prevent full length strakes in this region, the FIA also added two continuity clauses into the regulations (3.7.10).

This lays out demands that any bodywork in this central area must have a 'continuous curve'.

Article 3.7.10 c) covers this rear section of the car and states: "All bodywork that is visible from beneath the car and less than 50mm above the reference plane, within 250mm of the car centre plane and situated behind a line 175mm ahead of the rear wheel centre line, must produce only a single, continuous curve when intersected with any horizontal plane."

Read Also:

This is where McLaren obviously started to play the age old game of looking at one change within the regulations and seeing how it could play it off another, with its design reliant on the interplay of the new wording within the regulations.

In order that it can run these full height strakes, the design starts out as an extension of the transition wall between the reference and step planes, before forming the edge of the diffuser's boat tail section.

In terms of the continuity aspect, this diffuser design ticks the FIA's check boxes because if you were to take a slice through it at any point, it would form one continuous curve.

Had the strakes been disconnected from the boat tail, as they would normally be, they would break this continuity demand when a slice was taken through them.

This is also the reason as to why the strakes have a particular shape, as they follow the contours of the boat tail.

It's also why they don't have the feather-like slot treatment we see in the other strakes housed within the diffuser, as this would also break the continuity demand when you sliced through the section.

It should be mentioned that taking continuity into a design brief is by no means a new challenge for designers though, as they've had to hurdle similar challenges when designing their nose and sidepod bodywork for a number of years now.

Each of these areas is governed by a corresponding set of regulations regarding continuity to keep the solutions from being overtly complex.

McLaren MCL35M diffuser comparison

McLaren MCL35M diffuser comparison

Photo by: Uncredited

Interestingly, McLaren's use of these full length strakes is also combined with a redesign of the boat tail section bound within it, as the central section has been flattened out.

This not only lends itself to the easing of the continuity situation but perhaps plays its own role in lessening the aerodynamic impact of closing off the central channel from the flow outboard.

McLaren has undoubtedly opted for this solution as part of a larger redesign and repackaging of the diffuser, with the strakes just one element of a complicated area of the car.

The regulation changes to the floor and rear brake duct fins have also played a significant role in how the designers have had to rethink the overall design of the diffuser as they look to recoup the losses associated with the package of new rules.

And, whilst McLaren clearly believe it's the best solution for itself, it doesn't mean it is the only one to have looked at it.

Red Bull boss Christian Horner admitted in an interview with Sky Sports during the test: "I think it's something interesting, I think it's a concept we've looked at previously."

The idea, whilst interesting, is not one that will take long for teams to study, model, adapt and have their own versions of either, which is something that McLaren is acutely aware of.

Technical director James Key said last weekend: "I think the first port of call with any idea you see out there is CFD, so I think you can jump on an idea that you spot on another team within a week easily nowadays.

"Then it's really understanding how it works with your car, that's the key to this. You can then end up with a unique geometry of your own because you might understand the principle, but then you have to adapt it accordingly that it works with your car.

"So you'd probably therefore wind tunnel test it, which might be a week or two down the line and then you've got to manufacture it. So you could say between I suppose three and five weeks between taking the picture and putting it on the car if you really wanted to push this through".

This rapid turnaround of seeing an idea on a competitor's car to having a similar solution on its own comes down to the incredible tools that the teams now have at their disposal.

But, with the introduction of the cost cap and the sliding scale for CFD and windtunnel usage, teams will have to be more selective than ever about which avenues of development they decide to chase throughout a season.

 

shares
comments

Related video

2021 pre-season 'the best since Red Bull exists' - Marko

Previous article

2021 pre-season 'the best since Red Bull exists' - Marko

Next article

Stroll: Vettel "very wise" with feedback about Aston F1 car

Stroll: Vettel "very wise" with feedback about Aston F1 car
Load comments

About this article

Series Formula 1
Teams McLaren
Author Matt Somerfield
Why Bottas feels the time has come to be “more selfish” Prime

Why Bottas feels the time has come to be “more selfish”

We’ve seen five distinct versions of Valtteri Bottas at Mercedes as he’s tried to fulfil his own ambitions while being a consummate team player – two difficult, competing missions which have been challenging to reconcile. Speaking exclusively to Stuart Codling, Bottas explains his highs and lows… and why he still believes he can be world champion.

How long can Verstappen and Hamilton keep it clean? Prime

How long can Verstappen and Hamilton keep it clean?

Lewis Hamilton and Max Verstappen have been evenly matched so far in the 2021 Formula 1 title race. Neither has been afraid to get aggressive against each other on track, teeing up an enthralling contest as the year unwinds. But how long will their battle remain clean? Jonathan Noble ponders that exact point

Formula 1
May 13, 2021
How Brabham’s one-hit wonder was boxed into a corner Prime

How Brabham’s one-hit wonder was boxed into a corner

The Brabham BT46B raced once, won once, then vanished – or did it? STUART CODLING reveals the story of the car which was never actually banned…

Formula 1
May 11, 2021
The changes Barcelona needs to provide a modern-day F1 spectacle Prime

The changes Barcelona needs to provide a modern-day F1 spectacle

Formula 1’s visits to Circuit de Barcelona-Catalunya over recent years have been met with familiar criticisms despite tweaks here and there to the track to improve racing. With the 2021 Spanish Grand Prix largely going the same way, proper solutions need to be followed to achieve F1’s wider targets

Formula 1
May 10, 2021
Spanish Grand Prix Driver Ratings Prime

Spanish Grand Prix Driver Ratings

Often described as Formula 1's laboratory, the Circuit de Catalunya-Barcelona gave the clearest demonstration yet of the pecking order in 2021. And it's the key discrepancies from that order which illuminate who is excelling, and who needs to hit the reset button.

Formula 1
May 10, 2021
How Red Bull's deja vu set Hamilton on the winning path in Spain Prime

How Red Bull's deja vu set Hamilton on the winning path in Spain

An aggressive first corner move from Max Verstappen appeared to have set the Red Bull driver on course for victory in the Spanish Grand Prix. But canny strategy from Mercedes - combined with the absence of Red Bull's number two from the lead group - allowed Lewis Hamilton to pull off a demoralising reversal

Formula 1
May 10, 2021
The Barcelona practice times that prove Red Bull has hidden pace Prime

The Barcelona practice times that prove Red Bull has hidden pace

Lewis Hamilton led the way in Friday practice for the 2021 Spanish Grand Prix, but there was one major encouraging sign for Red Bull. However, making good on that gain will require Max Verstappen to avoid repeating a mistake that left him well down the FP2 order...

Formula 1
May 7, 2021
Why McLaren doesn’t doubt Ricciardo can escape his ‘dark’ place Prime

Why McLaren doesn’t doubt Ricciardo can escape his ‘dark’ place

Three points finishes from as many starts represents a decent opening innings on paper, but Daniel Ricciardo has endured a tough start to his McLaren career - only magnified his teammate's excellent form. Yet both he and the team have good reason to expect a turnaround soon.

Formula 1
May 6, 2021