Giorgio Piola's F1 technical analysis
Topic

Giorgio Piola's F1 technical analysis

2019 tech verdict: Ferrari founders, but then finds form

Join us as we delve into Giorgio Piola’s 2019 archive and bring you insight into the relentless development undertaken by the teams throughout a season in the pursuit of more performance. In today’s gallery we will focus on… Ferrari.

2019 tech verdict: Ferrari founders, but then finds form

After winning the pre-season testing war, this was the year that Ferrari was supposed to truly challenge Mercedes for the world championship. So what went wrong?

Besides Bahrain, where newcomer Charles Leclerc was robbed of a first win due to an engine problem, its early-season form was poor and a lack of downforce was apparent. Only when the season hit the lower-downforce or power-dependent circuits – like Montreal, the Red Bull Ring, Spa and Monza – did the slippery SF90 truly come into its own.

Its power output soon became a focus of attention, with rivals seeking FIA technical clarifications in an attempt to negate its advantage. Ferrari did make decent steps with its car’s balance and downforce levels as the season developed, proved by Sebastian Vettel's win in Singapore, but by the time it was in a position to challenge Mercedes the title race was already over.

Click on the arrows on the images below to scroll through them…

Ferrari SF90 side detail
Ferrari SF90 side detail
1/17

Photo by: Giorgio Piola

Ferrari’s sidepod and cooling game really lifted back in 2017 when it was the first to adopt the low-slung side impact spar and pushed back sidepod inlet. The regulation changes for 2019 were widesweeping but none had a severe effect on this area of the car, so gains here might be seen as minimal. Ferrari was still keen to make improvements here though, utilising a flow-through duct alongside the chassis (blue arrow), while also following on from the example set by others when it comes to using the tail-end of the halo transition for cooling.
Ferrari SF90 floor
Ferrari SF90 floor
2/17

Photo by: Giorgio Piola

Having already tested vertical fins on the floor ahead of the rear wheels at Austin in 2018, the team pushed on with the concept for 2019. The fins help to improve flow circulation ahead of the rear wheels, helping to reduce the negative aerodynamic impact that the wheel wake and tyre squirt can create.
Ferrari SF90 DRS
Ferrari SF90 DRS
3/17

Photo by: Giorgio Piola

Ferrari, like several other teams, used a tail section on the DRS pod for 2019. This stabilises the rear wing when DRS is activated, preventing the flap from over-extending.
Ferrari SF90 front brakes comparison
Ferrari SF90 front brakes comparison
4/17

Photo by: Giorgio Piola

For a number of years Ferrari has been using a blown axle solution (inset) which collected airflow at the inlet and fed it through the centre of the wheel to reduce the aerodynamic wake created by the wheel and tyre that can have a negative effect on the rest of the car. With blown axles banned for 2019, the team looked for ways to recover some of the effects it previously enjoyed and so expanded on the outer channels that drive airflow through the wheel rim instead.
Ferrari SF90 floor Azerbaijan GP
Ferrari SF90 floor Azerbaijan GP
5/17

Photo by: Giorgio Piola

Further development of the floor slots ahead of the rear wheels was undertaken for the Azerbaijan GP, with the rearmost slot extended all the way across to the vertical strake and another slot added on the other side of it.
Ferrari SF90 detail front wing Azerbaijan GP
Ferrari SF90 detail front wing Azerbaijan GP
6/17

Photo by: Giorgio Piola

Ferrari’s front wing is the unloaded variant – a design that sees the outer portion of the wing reduced in height near the endplate to reduce the strength of the vortex created here.
Ferrari SF90 front wing endplate
Ferrari SF90 front wing endplate
7/17

Photo by: Giorgio Piola

For the Spanish GP, Ferrari decided to make some alterations to the front wing, changing the bend in the endplate, whilst also adding a small triangular Gurney-like tab before the trailing edge of the footplate.
Ferrari SF90 front wing endplate comparsion
Ferrari SF90 front wing endplate comparsion
8/17

Photo by: Giorgio Piola

The changes seen here from the side also show how a notch was removed from the upper rear corner of the endplate too.
Ferrari SF90 front brakes, Austrian GP
Ferrari SF90 front brakes, Austrian GP
9/17

Photo by: Giorgio Piola

Seen here at the Austrian GP, Ferrari used a scalloped face on the brake disc when it needed maximum cooling, as this design increased the total surface area available.
Ferrari SF90, rear wing endplate
Ferrari SF90, rear wing endplate
10/17

Photo by: Giorgio Piola

This illustration of the rear wing from the Austrian GP shows how the team used multiple strakes on the upper section of the endplate to improve the overall performance of the wing.
Ferrari SF90, nose
Ferrari SF90, nose
11/17

Photo by: Giorgio Piola

The team also made changes to the nose and turning vanes for the Austrian GP, with an additional longitudinal strake added at the base of the wing pillars to help improve flow around and through the slots, while the rear vane usually hung from the underside of the nose was moved back onto the chassis.
Ferrari SF90, nose
Ferrari SF90, nose
12/17

Photo by: Giorgio Piola

This rearward image of the front wing pillars affords a better view of the strake introduced to help with airflow management.
Ferrari SF90, bargeboard
Ferrari SF90, bargeboard
13/17

Photo by: Giorgio Piola

The team introduced a new bargeboard arrangement for the Hungarian GP in an effort to improve downforce deficiencies.
Ferrari SF90 front wing
Ferrari SF90 front wing
14/17

Photo by: Giorgio Piola

Already the cream of the crop in a straightline, the Scuderia were looking to devastate rivals at the ‘Temple of Speed’ and ran with an extremely skinny upper flap configuration at Monza.
Ferrari SF90, front wing comparison
Ferrari SF90, front wing comparison
15/17

Photo by: Giorgio Piola

In a bid to resolve its higher downforce woes, the Scuderia installed a new nose solution for the Singapore GP, which incorporated the under-nose cape solution used widely up and down the grid. This side-by-side comparison gives us a clearer understanding of how it achieved its installation with the cape integrated into the front wing pillars.
Ferrari SF90, floor
Ferrari SF90, floor
16/17

Photo by: Giorgio Piola

Ferrari made further changes to its floor in a bid to improve downforce and aerodynamic consistency too, integrating metal stiffeners in the floor where it was prone to flexing under load.
Ferrari SF90, exhausts comparison
Ferrari SF90, exhausts comparison
17/17
With an eye on 2020, Ferrari arrived at the last race of the season with a new solution to test that sees the wastegate pipework once again split into two. It bears a significant resemblance to the design that Red Bull ran in the latter phases of its campaign with the tailpipes turned up to face the underside of the wing.

Read Also:

shares
comments
Video: An in-depth look at Sainz's home simulator set-up

Previous article

Video: An in-depth look at Sainz's home simulator set-up

Next article

Kubica: Tough 2019 season worth it to "close a chapter"

Kubica: Tough 2019 season worth it to "close a chapter"
Load comments
How Monza only added more questions to F1's sprint race conundrum Prime

How Monza only added more questions to F1's sprint race conundrum

With two sprint races under its belt, Formula 1 must now consider its options for them going forward. While they've helped deliver exciting racing on Sundays, the sprints themselves have been somewhat lacking - creating yet another conundrum for F1 to solve...

Who should Alfa Romeo sign for 2022's F1 season? Prime

Who should Alfa Romeo sign for 2022's F1 season?

OPINION: With Valtteri Bottas already signed up for 2022, all eyes are on the race for the second seat at Alfa Romeo next year. Antonio Giovinazzi is the current incumbent, but faces a tough competition from appealing short and long-term prospects

Formula 1
Sep 15, 2021
The "forced break" that was key to Ricciardo's Monza excellence Prime

The "forced break" that was key to Ricciardo's Monza excellence

OPINION: Daniel Ricciardo has long been considered one of Formula 1's elite drivers. But his struggles at McLaren since switching from Renault for 2021 have been painful to watch at times. Yet he's recovered to banish those memories with a famous Monza win – built on a critically important foundation

Formula 1
Sep 14, 2021
Italian Grand Prix driver ratings Prime

Italian Grand Prix driver ratings

Two drivers produced faultless performances as, for the second year in a row, Monza threw up an unpredictable result that left many to rue what might have been

Formula 1
Sep 13, 2021
Why Ricciardo would have won without Verstappen/Hamilton crash Prime

Why Ricciardo would have won without Verstappen/Hamilton crash

The clash between Max Verstappen and Lewis Hamilton was the major flashpoint the 2021 Italian Grand Prix will be remembered for. Yet by this point, race leader Daniel Ricciardo had already done the hard work that would put him in position to end his and McLaren's lengthy win droughts, on a memorable afternoon in Monza

Formula 1
Sep 13, 2021
Why Italian GP success is on for McLaren even if Verstappen dominates Prime

Why Italian GP success is on for McLaren even if Verstappen dominates

For the second time in 2021, McLaren will line up for the start of a grand prix from the first row. It knows it has the chance of "glory" if things go well for Daniel Ricciardo and Lando Norris at the start of the 2021 Italian Grand Prix, but even if they just maintain their grid positions, signs from the rest of the Monza weekend suggest success is very possible for Formula 1's other orange army

Formula 1
Sep 12, 2021
How Formula 1 has made itself unattractive to new teams Prime

How Formula 1 has made itself unattractive to new teams

OPINION: The Formula 1 cost cap has been billed as a saviour to several teams and helped to guarantee their viability for investors. But there already exists another mechanism that effectively had the same purpose, and serves as a strong deterrent for those with the means to go it alone in setting up a new team

Formula 1
Sep 10, 2021
How Schumacher's first year marked him out as F1's king in-waiting Prime

How Schumacher's first year marked him out as F1's king in-waiting

After his sparkling F1 debut with Jordan at Spa, Michael Schumacher quickly leapt to Benetton for the 1991 Italian Grand Prix. This move paved the way for the German to win his first grand prix one year later and laid the foundations for his ascent to become a title contender by 1994.

Formula 1
Sep 10, 2021